(juan)、活性炭吔R(ge)(zhao)品概q?/span>
(mo)(mo)(mo)(mo)zL炭(e)(e)(e)(yang)(yang)R器又活性炭(e)(e)(e)(yang)(yang)R装置性炭(e)(e)(e)(yang)(yang)R器、(gui)(chun)性炭(e)(e)(e)qo器主要()于有机气的处理，主是吸器Q(han)(yang)(yang)穿()(shan)(mo)(mo)(gui)(chun)性炭(e)(e)(e)(yang)(yang)R层等部g(mo)(mo)本装置采用不锈板镀锌钢ѝA3钢P(chan)P(shou)等质而成本装置用于家兗业、(huo)革、五金徏等业的有机处理?/span>
二活性炭吔R器工作原?/span>
(mo)(mo)(mo)(mo)有机废l(qi)(liao)(ban)后Q(ben)(ben)(ben)(han)风机负用下进活炭(e)(yang)(yang)R(tao)(tao)器。活炭(e)(yang)(yang)R(tao)(tao)(tuan)利()活炭(e)的孔()，(ren)(ren)存在力的理发的由于固表面上存在未^(chen)(chen)饱和的分子力或学键力Q(ben)(ben)(ben)(han)此当此固表面与气接触Ӟ(ren)(ren)(hao)p(yang)(yang)(gao)气分子Q(ben)(ben)(ben)(wu)(wei)浓ƈ保持在固表面，(ren)(ren)q(zan)现象是R(tao)(tao)现象本工艺所采用的活炭(e)(yang)(yang)R(tao)(tao)法就利()固表面的q(zan)(hao)质Q(ben)(ben)(ben)(han)(hong)(hong)废与大面U的多孔活炭(e)(sui)接，(ren)(ren)废中的污染被R(tao)(tao)在活炭(e)Z(hong)(hong)(chen)(chen)面Q(ben)(ben)(ben)(wu)(yao)(wu)气合分，(ren)(ren)辑净的的?/span>
三、(gui)(hao)炭R器设组成部?/span>
zL炭R讑()活性炭R(zhao)?孔板、活性炭R? 、离心风机、电控箱、风道、排气筒{部组成?/span>
(mo)(mo)zL炭吔R器设备组示意图
四、活性炭吔R(zhao)操作与使用
(mo)(mo)(一)操作前检?/span>
1.查活性炭是否装;
2.查炭吔R(tao)成套装置各活动门((hong)?(tuan)否在扣紧状?
3.(gui)查电机是否正?(juan)要是离风?;
4.(mo)机架q零g及螺栓无松动，应随时予以调整紧?
(?(na)作q(ma)程
(mo)(mo)1.(yang)上甉|开养I(chou)甉|(juan)(yun)灯亮;
2.风机按向x转，(ren)讑֤指示亮;
3.讑֤指灯亮后，风机始运?
4.风启动后辑常转速时Q(han)在运转过E(fu)(yu)l(gan)(fu)(mo)u(jia)(kua)度是否正?
(mo)(mo)5.风机q(ma)(song){时注意电力及电|如异需q(ma)(du)修?/span>
(mo)(mo)五性炭R器操作注事?/span>
1.(hong)有在风完全正的情况下()(hong)运?
2.(she)正常运转中Q活性炭吔R(tao)成套置各(e)门必紧;
3.如风备在修后开动时Q则必注意风各位是否正?
(mo)(mo)4.定期更zL炭Q饱和的zL炭吔R(ge)效率降Q应定期从下料口出Q重新的活性炭更换周期要Ҏ实际情况定;
(mo)(mo)5.定期风是否正常，防止风机轴温度q高?
6.(juan)确h(han)w安全，(ren)(she)活性炭(e)吔R成套内作时必须停车时q(ma)(du);
7.(she)设备运过E中Q如现不常冉|(lu)应立卌检查，(ren)若是故障应查明原因q设法消，(ren)(hong)现大故障应立停R(jian)修?/span>
微信公众?/p>
官方微博
手机二维?/p>
